Product ID:DOD-E-699D 26008 GRAY
MSDS Date:06/01/1990
FSC:8010
NIIN:00-286-9083
MSDS Number: BJYWB

KOP-COAT INC

436 7TH AVE
PITTSBURGH, PA 15219
US

Emergency Phone: 800-548-0489/412-227-2700

Info Phone: 800-547-2468/800-424-9300

Preparer: C.A. HOPE

Cage: 00297

KOP-COAT INC

PITTSBURGH, PA 15219-1818 US

Telephone: 800-553-5631, CHEMTREC 800-424-9300

Cage: 00297

PETROLEUM DISTILLATES

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 5-10%

OSHA PEL 400 PPM;1600 MG/M3

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 10-15%

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 10-15%

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 1-5%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 5-10%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN

CAS: 61790-53-2

RTECS: HL8600000

Fraction By Weight: 1-5%

OSHA PEL 20 MPPCF

ACGIH TLV: 10 MG/M3 TDUST; 9293

TALC

CAS: 14807-96-6

RTECS: VV7720000

Fraction By Weight: 5-10%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 20-25%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

VOC 3.1 LBS/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:EYE: DIRECT CONTACT W/LIQUID OR VAPOR
MAY CAUSE IRRITATION. SKIN: PROLONGED AND/OR REPEATED CONTACT
W/SKIN MAY CAUSE DEFATTING. INHALE: INHALATION OF HIGH
CONCENTRATIONS OF VAPORS MAY CAUSE RESPIRATOR Y TRACT IRRITATION,
CENTRAL NERVOUS SYSTEM DEPRESSION & LUNG CHANGES. INGEST: MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS A POTENTIAL
CARCINOGEN.
Effects of Overexposure:SKIN: REDNESS, CRACKING, BLISTERING, IRRITATION
AND DERMATITIS. INHALATION: HEADACHE, WEAKNESS, DIZZINESS,
INCOORDINATION AND POSSIBLE COLLAPSE. INGESTION: NAUSEA, VOMITING,
DIARRHEA AND EFFECTS SIMIL AR TO THOSE DESCRIBED UNDER
INHALATION.ASPIRATION OF MATERIAL INTO LUNGS MAY CAUSE CHEMICAL
PNEUMONITIS/POSSIBLY FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASE IN OR A
HISTORY OF AILMENTS INVOLVING: SKIN, EYE, RESPIRATORY TRACT, LIVER,
KIDNEY, CENTRAL NERVOUS SYSTEM ARE AT A GREATER THAN NORMAL RISK OF
DEVELOPING ADVERSE EFFECTS.

First Aid:EYE: IMMEDIATELY FLUSH W/LG AMT WATER-15 MINUTES. SKIN: WASH
THOROUGHLY W/SOAP & WATER. WASH CONTAMINTAED CLOTHING BEFORE REUSE.
INHALATION: REMOVE FROM EXPOS. IF BREATH STOPS/DIFFICULT, GIVE CPR
OR O XYGEN AS NEEDED. INGESTION: DO NOT INDUCE VOMIT. GIVE 1 GLASS
MILK OR 1-2 OZ ACTIVATED CHARCOAL IN WATER AS TOLERATED. DON'T GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON. SEEK MEDICAL ATTEN AS
NEEDED.

Flash Point:102F,39C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY,
ALCOHOL OR FOAM. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR COMPLETE FIRE SERVICE PROTECTIVE
EQUIPMENT, INCLUDING FULL-FACE MSHA/NIOSH APPROVED SCBA. USE WATER
TO COOL FIRE-EXPOSED CONTAINER/PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:VAPORS FORM FLAMM/EXPLOS MIX IN AIR/MAY
TRAVEL TO IGNITE SOURCE-FLASH. CONTAINERS MAY CONTAIN
FLAMMABLE/EXPLOSIVE VAPORS. CLOSED CONTAINER MAY EXPLODE W/HEAT.

Spill Release Procedures:STOP SPILL/LEAK (REPORTABLE AMT-100 LBS OR
MORE) IF NO RISK INVOLVED. AVOID BREATHING VAPORS/CONTACT W/HOT
LIQUID/ FUMES. REMOVE IGNITION SOURCES. VENT AREA. TAKE UP
CAREFULLY TO AVOID HEAT AND SPARKS . USE INERT ABSORBENT TO
COMPLETE CLEAN-UP. REACTS

Handling and Storage Precautions:AVOID PROLONGED OR REPEATED CONTACT
W/SKIN OR EYES/BREATHING VAPORS, MISTS OR FUMES. HANDLE & USE PER
LOCAL CODES. SPRAY PAINT PER OSHA 29CF1910.107.
Other Precautions:STORE IN AREAS/BUILDINGS DESIGNED TO COMPLY W/OSHA
1910.106. KEEP IN A CLOSED, LABELED CONTAINER WITHIN A COOL,
WELL-SHADED, DRY, VENTILATED AREA. PROTECT FROM PHYSICAL DAMAGE.
KEEP CONTAINER CLOSED W HEN NOT IN USE. GROUND AND BOND DRUMS.

Respiratory Protection:IF VENT DOESN'T KEEP INHALATION EXPOS BELOW PEL
(TLV), USE MSHA/NIOSH APPROVED UNITS PER 29 CFR 1910.134,
INSTRUCTIONS/ WARNINGS & NIOSH-RESPIRATOR DECISION LOGIC-PUB
87.108. IF WITHIN OSHA PROTECTION FACTOR, AIR PURIFYING OV/FILTER
UNITS O
Ventilation:SUFFICIENT VENT TO KEEP EXPOSURES BELOW CURRENT EXPOS LIM
AND AREAS BELOW FLAMM VAPOR CONC. USE LOC EXHAUST IF CONFINED.
Protective Gloves:HEAVY DUTY NEOPRENE OR EQUIVALENT.
Eye Protection:SAFETY GLASSES, MINIMUM
Other Protective Equipment:WEAR INDUSTRIAL TYPE WORK CLOTH/SAFETY
FOOTWEAR.MAY NEED HEAD/NECK COVER, APRONS, JACKETS, PANTS,
COVERALLS, BOOTS, ETC.
Work Hygienic Practices:MAINTAIN GOOD HOUSEKEEPING.WASH EXPOSED AREAS
PROMPTLY/THOROUGHLY BEFORE EATING, DRINKING, USING TOBACCO PRDCT,
RESTROOM
Supplemental Safety and Health
W/OXIDIZING MAT'L.IF SPILLED, REPORT TO NAT'L RESPONSE CTR.DO NOT USE
PRESSURE TO EMPTY DRUMS,CUT,DRILL,GRIND,WELD ON/NEAR FULL/EMPTY
CNTNRS.DISCARD CONTAM FOOTWEAR.DO NOT USE UNLESS FULLY UNDERSTOOD.
UNDER FIRE CONDITIONS,MAY EMIT IRRIT/TOXIC GAS/FUMES.EMPTY
CONTAINERS MAY RETAIN RESIDUE INCLUDING FLAMM/EXPLOS VAPOR.

HCC:F4
Vapor Density:>1
Spec Gravity:10.5 LBS/GAL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID WITH A TYPICAL SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE UPON
THERMAL DECOMPOSITION.

Waste Disposal Methods:THIS PRODUCT IS A US EPA DEFINED IGNITABLE
HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE HAZARDOUS WASTE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.